Search results

brake line for Tahoe If the job is not already done, InLine Tube or Classic Tube may be able to help.

no start condition Does the starter energize and turn the engine so it sounds like it is trying to start or does it seem the same as when there is a dead battery?

The seal was replaced on the rear output shaft of the transfer case and started to leak after only about 1500 miles. A new seal was installed last week. I noticed that the face of the drive shaft yoke contacts the seal at all times. See two attached photos. Is this normal? It seems this is a...

Solution The problem was traced to a bad power seat switch that was continuing to send power to the seat drive motor after it was at the mechanical limit on the track. With the power seat wires now disconnected at the connector under the seat, the rapid current drain problem is gone. A new seat...

I have a 1996 Tahoe 4WD, 2 door w/ 5.7L (350C.I.) gas engine. Odometer is at 157k miles. The truck was running great. I tend to use it only on weekends and it usually sits all week. Last weekend the one year old battery was dead and would not take a charge from the charger. I put a new battery...

Needed to get a new tank for two reasons. Old tank had some significant rust. However, the major reason was that I could not get the locking ring loosened up and mistakenly removed the locking ring retaining fixture which was spot welded to the tank. The two issues combined led me do go for a...

Closure Finished the job today and the truck runs great! As for the electrical anomaly, after checking the gray power supply wire to the fuel pump all the way along its routing, I added a jumper wire from the terminal block stud (battery voltage) to the socket where PIN #30 of the fuel pump...

Good idea. Yes, replaced the pigtail where the harness connects to the new fuel pump and sender 3 pin (+ ground) connector. Thanks, Ken

Thanks for the suggestion. Will report back once I have it all sorted out.

This is about my '96 Tahoe LT 2 Dr. 4WD 5.7L (350 c.i.) with 134k miles. I drove the truck about 75 miles during which it was running great w/ all gauges reading normal. I had 1/4 tank of gas. After parking the truck for about 2 hours I then went to start it for the drive toward home. It cranked...

Fuel pump relay meltdown Saw your thread from August '08. Were you able sort out the root cause of the melted fuel pump relay problem? Curiouse what was going on with your 1996 truck. Thanks, Ken '96 Tahoe 2 dr. 4WD